恩施附近有没有服务

Hello, welcome to Ningjin Shengda baler machinery factory!

Add to collection | About us | contact us | Website map

 Waste paper packer

National hotline thirteen billion one hundred and forty-five million three hundred and forty-four thousand and one hundred

Current location: Baler > news information >

How much is a waste paper packer?

Author: admin Release time: 2020-08-05 16:27 Number of visits:

In the normal application of waste paper packer, pay attention to the touch screen of automatic baler, and ensure the following contents:

It is not necessary to open the rear shell of the touch screen of the waste paper packer. Do not put magnets, motors and other magnetic objects close to the touch screen. It is forbidden to touch the surface of the control screen with hard objects. Do not splash the etching liquid on the touch screen. Before installing, disassembling and cleaning the waste paper packer, the power should be cut off. Regularly maintain the air vent on the rear shell of the touch screen of waste paper packer to keep the vent smooth.

The common faults of gasoline pump in waste paper packer include common faults of gasoline pump, common faults of suction and delivery pipe, common faults of oil tank filtering device, and common faults of oil pump motor. If the gasoline pump of waste paper packer does not drain oil, check the fault detection successively according to the following methods.

 Waste paper packing machine

1. If the rotation direction is not correct, stop immediately and change the rotation direction of the motor, such as burning or damaging the gasoline pump again.

2. The gasoline pump of the waste paper packer did not rotate. Repair the coupling.

3. The pump shaft is broken and the motor rotor does not rotate. Repair the gasoline pump.

4. The suction pipe is blocked. Check the suction pipe.

5. The filter device of oil tank is blocked, and the filter device shall be cleaned or replaced.

6. The volume of the oil tank filter device is not enough, which is about 2 times of the pump volume.

7. The viscosity of No.46 hydraulic oil of waste paper packer is too high. Remove the oil type and set the electric heater.

8. The rated power of waste paper packer motor is not enough, and the motor with speed ratio required by gasoline pump shall be replaced.

 Real shot of waste paper packer

9. The sealing of suction pipe of gasoline pump is not good, and the suction pipe of steam inspection is found.

The oil level of the oil tank should be redesigned with the oil level higher than 10.

11. The gasoline pump blade cannot slide out of the rotor slot of the motor. Repair the gasoline pump or replace the gasoline pump.